|
|
|
|
GMC EMERGENCY REPAIR KIT - COMPILED BY BOB DESAUSSURE
Part Mfg & # Mfg & # Mfg & # Quantity Supplier Year List Price
Engine Approx.
Points GM 2336659 Delco D106P 1 1,3 73-74 10.85
GM 12338665 Delco D204 1 1,3 73-74 4.'57
Cap GM12338067 Delco 306R 1 1,3 73-74 14.95
Rotor . GM1233867 Delco D426R 1 1,3 73-74 5.55
Coil GM12337166 Delco U505 1 1,3 73.74 33.25
HEI Module GM1875990 Delco D1906 1 1,3 75-78 59.82
Term. w/cap GM1802261 Delco D1906 1 1,3 75-78 14.73
Cap GM197440B Delco D336 1 1,3 75.78 22.24
Coil GM1965474 Delco D531 1 1,3 75-78 54.54
Roar GM1049615C: Delco D448 1 1,3 75-78 7.26
Fuel Pump GM47142 Delco D41556 1 1,3 73.77 40.86
Fuel Filter GM5650906 Delco GF441 1,3 2.84
or A/C GF61P Larger 1 K Mart 2.00
Spark Plug GM56513882 Delco R46SZ Gap 60 2 3 2.15
Spark Plug Wires For Emergency 34" Long 2 3
Fan Clutch 455 Hayden2749 1 3 80.00
Fan Clutch 403 GM724457 1 1 150.00
* Ign. Switch GM1990116 Delco D1405B (Not Keyed Switch) 17.45
Starter Repair Kit Blue Chip Manufacturing #627401 1 3 12.00
Batt.Cable Connector 1 3
Jumper Wire For Hse. Batt. to Ignit. At Crossover Switch 18")(14 G w/ Alligator Clips to run on if Alt. Fails
Kit Plastic Vac. Line 'T's Etc. 1 3 2.00
Fuses glass 15 to 30 Amp 8 3
Upper Radiator Hose GM689921 1 1 20.00
Lower Radiator Hose GM689922 1 1 20.00
Metal Tubing 1 5/8" & 1 3/4" x 4" For Quick Fix 1 ea. ( for upper & lower rad. hose )
Stainless Clamps #M24 4 4
Belts GM (Gdyer Set 1,3
Fan & Power Steering 455 7450 15456 1 1,3 12.00
..... 403 10034695 15486 12.00
Air Cond. ........ 455 7619 15634 1 1,3 12.00
..... 403 7603 15800 12.00
Alternator ...455 7570 15581 1 1,3 12.00
.... 403 9433767 15581 12.00
Oil System
1. Airoquip. Hose FC35008 With 190223 Elbow Fitting & 190285 Straight Fitting 24" Long 35.00
Oil Filter GM 6437462 Delco PF24 1 3 5.26
(above for 455-433, has 2 more lines, should be converted to same as 455. See Coach Talk 1/89)
Suspension System
#6 Easy Out for removing air bag fitting 1 5
1 1/8" Deep Socket For Air Bag Removal 1 3
17" x 3/4" bolt 5" each end 4 nuts 3/4 nat. fine) 1 5 (replaces air bag)
* CV Boot Motor Mite #03809 Speadi Boot 1 3
(quick and good, do not substitute another brand, Call 215-997-1800 for nearest dealer) 25.00
* Spare Air Bag With Fittings 1 1,6 75.00
* Parker Quick Connectors #2P61462PL-4 or "Roadsplice" 2 For Air Line 2.00
Piece 24" plastic air line 1/4" by Simplex (get from truck repair shops) Leaks 2.00
Shrader valve with stems for air bags 62214695 2 1,3
* Air Compressor Belt Dana 2000632 1 1 9.25
12 Volt DC 100 lbs. Min. air pump and appropriate cord 3,5 30-50.00
Generator 6 Kw.
* Bridge Rectifier GM707164 - ONAN 3050517 1 1 24.00
Filter Oil Delco PF56 1 1,3,4
Filter Gas GM 149-1445 1,3
Fluids
Dot3 brake fluid, Ford hvy duty C6AZ19542A 1 Pint 5.00
Trans Fluid Dextron #3 GM Spec or equal 1 Pint 3 3.95
Steering Fluid GM Spec or equal. 1 Pint 3 2.75
Engine Oil GM Spec or equal 2 Qts. 3
Fuel Filter Nut Gasket GM7024281 1,3
Anti Freeze 1 Qt. 3
Fresh Water System
GMC EMERGENCY REPAIR KIT - (CONTINUED)
Pan Mfg & # Mfg & # Mfg & # Quantity Supplier Year List Price
24" x 1/2" ID Reinforced Vinyl Hose 1 Piece 4
3" x 1/2" 0 D Copper Tube & 4 #10 Stainless Clamps 2 Pieces 4,5
* Kit For Repairing F. W. Pump ( your brand ) 1 4 16-25.00
Pre Heat Water System & Fuel Lines
Heavy Duty Heater Hose 5/8" ID x 24" 1 Piece 4
Heavy Duty Heater Hose 3/4" x 24" 1 Piece 4
3" x 5/8" 0 D Copper Tube & 4 #12 Hoes Clamps 2 Pieces 4,5
Tapered Wood Plugs 3/4" to 1/2" x4" 2
36" x 3/8" I D Gas Line Hose 1 Piece 4
3" X 3/8" O D Copper Tube 2 Pieces 4,5
#10 Stainless Steel Clamps 4 4
Gas Filler Cap 1 3
Miscellaneous
5' # 10 Insulated Wire 5
5' # 16 Insulated wire 5
Small Roll Electric Tape 1 5
Small Roll Teflon Tape 1 5
Nylon Ties Various Sizes 12 5
Can Permatex Form A Seal #82096 1 3
Epoxy Pads Locktite #44581 2 3
Silicone Spray Lubricant 1 Can 3,5
Marine Silicone Caulk 1 Tube 4
Epoxy Paste or Filler 1 Tube 4
#6000 Glue Elect. Prod. Inc. 1 Tube 7
Bearing Grease& Applicator GM Spec. or equal 1 Tube 3
Duct Tape Small 2" Wide 1 Roll 3,5
Dielectric Grease, Small Radio Shack 276-1372 1 Tube 3
White Grease, Small 1 Tube 3
#22 Gauge Wire, Stainless Small 1 Roll 5
Numa Fix For Radiator 2 Tubes 3
Small Assort. Screws, Nuts & Bolts 5
Anti Freeze 1 Gal. 3
For Extended Trips, Outback or The Alcan Highway
Waterpump GM12337519 Delco251-321 or 1 1,3 90.88
Waterpump Airteck#1120 Option Loaded Hvy Duty 1 3 80.00
Kit For Alternator Repair Your Amperage & Model 1 2 12.00
Front Flex Brake Lines GNW9758214 2 1 3 35.00
* Rear Flex Brake Lines GM#9757643 2 1 95.00
Rear Wheel Brake Cyl. 15/16 Wagner #F51081 1 1,3 36.00
Rear Wheel Brake Cyl. 1 1/16Wagner #F79767 1 1,3 35.00
Brake Master Cylinder GM 548867 Wagner F79621 1 1,3 40.00
Front Brake Caliper Kit, GM#25509422 Delco 173-144 1,3 20.67
* Brake Combo Valve Delco 172-1353 1 64.75
Spare Head Light Bulb 6014 or Halogen 6024 3 4-13.00
Rear and Front Shock Absorber with Bolts & Nuts 1 ea 3 GM # Only 60.00
Suppliers
1) Cinnabar Parts 1-800-720-2227 (24 Hr. Service U.S.), Wes Caughlan Tech. Assistance 415-948-8664 Service 810-646-2444
2), Blue Chip 1-800-523-8905 (for dealer)
3) Parts House
4) Marine Suppliers
5) Hardware Outlets
6) GMC Specialty Supplies of After Mkt. Products for GMC Motor Homes
7) Tap Plastic (or other plastic supplier)
While the above list of emergency parts may look overpowering, we can assure you every piece has frequently saved someone a
lot of time and trouble. If you can't install them yourself, a good tow truck operator can. Many of the parts can be assembled
from your own coach on replacement of your existing pieces that have approached their time and mileage limits but are still
serviceable. Pack and preserve in the pod for your use or that of a fellow traveler. We have yet to attend a Rally
(Western, Internat., or Club) where some of the above items were not put to good use. The items with asterisks (*) are not readily
available from parts houses and will cause delays on the road. With all of this on board you can handle most of your problems.
|
|
|